3 pass vs 4 pass boiler

3 pass vs 4 pass boiler

ZOZEN's main products include industrial boilers, power station boilers, waste heat recovery devices (HRSG), special waste heat boilers, pressure vessels and other five series with more than 400 varieties of specifications, mainly classified as: 10 ~ 220 t/h series power station boilers; SHL series bulk coal-fired Steam and hot water boilers; SZL series pipe assembly boilers; DZL series shell boilers; WNS series, SZS series of oil/gas fired boilers; YLL series of coal-fired thermal fluid heater; YYW series of fuel gas thermal fluid heater; biomass fuel boiler steam and gas combined cycle waste heat boilers, special waste heat boilers and so on.


ZOZEN has built six fully automatic lines for the production of convection pipe, coil pipe, threaded pipe, membrane wall, serpentine tube and header. The parts so produced have consistent dimensions that enable easy assembly and ten years’ extension of a boiler’s life.

Our Lastest Boiler Type

Seven Hold Points

Seven hold points are set and each one is supervised by a responsible inspector. Any work that fails to pass the inspection cannot proceed until the inspector is able to verify its quality.

1,Incoming materials are inspected again upon entry into the plant.

2,Material markings will be transferred to all cut pieces to ensure identification and traceability.

3,Test pieces are used to ensure a higher success rate in welding.

Unique structural design

National Precision Bearing offers stainless steel for applications that require corrosion resistance.We have world class manufacuring facilities using latest technology, machines and equipments.

Contact Us

Answers - The Most Trusted Place for Answerin

Answers is the place to go to get the answers you need and to ask the questions you want

Contact us

HVAC State and Local Licensing Requiremen

There aren’t a lot of building trades that require you to hold more than one card. That can’t be said for the HVAC trade. One of the biggest gripes out there is the sheer number of certifications a guys has to hold to stay above board in the HVAC industry

Contact us

Trane vs Carrier vs Lennox Furnace Review 20

Trane, Carrier and Lennox are the “Big 3” of the HVAC world. Their large market shares are fueled by quality, efficient products and huge marketing budgets.

Contact us

Visual Pump Glossary - pumpfundamenta

ANSI B73.1: this is a standard that applies to the construction of end-suction pumps.It is the intent of this standard that pumps of all sources of supply shall be dimensionnally interchangeable with respect to mounting dimensions, size and location of suction and discharge nozzles, input shafts, baseplates, and foundation bolts.

Contact us

PLC vs Arduino Show Down | Hackad

there is a good 4-20mA loop to arduino conversion totorial(ish) video over at [AVE’s] youtube channel, seems not that big of an issue. I believe [AVE] was looking into a pressure gauge for a

Contact us

Cold process vs hot process - which one to choos

Cold process vs hot process at some point, each soapmaker asks which one is better or when they should be used. But before I give you some arguments, I will explain these two techniques a bit more in detail - it is crucial for understanding their advantages and disadvantages.

Contact us

MHI Superheated Steam Generators One Atmospher

What is superheated steam? What is saturated steam? When water molecules exist in a gaseous-state at a temperature above the boiling temperature of water, it is called the superheated steam-state.When at the boiling-temperature, the steam is called saturated steam.

Contact us

Improving Boiler Room Efficiencies - Federa

; David Farthing’s TechStuff Rev.12 ‘The effect of Feedwater Temperature on Boiler Output’. The analysis below exemplifies the direct effect of feedwater temperature on boiler output. Note the factory rating at 212 degrees versus the original as observed feedwater temperature of 180 degrees.

Contact us

Pages - Steam Accumulators - Spirax Sar

Steam Accumulators. The purpose of a steam accumulator is to release steam when the demand is greater than the boiler’s ability to supply at that

Contact us

Thermal Power Plant Working | Indian Powe

Introductory overview. In a coal based power plant coal is transported from coal mines to the power plant by railway in wagons or in a merry-go-round system.

Contact us

DB-3/4 – Differential Bypass Valve - Xylem Applie

The differential bypass valve is used in systems where heating loads may be excluded from the circuit as zone valves close. It controls the excess flow in the system by acting as a bypass while ensuring adequate flow to the remaining open circuits.

Contact us

What is the Purpose of Minimum Flow? - ekwestrel co

I have more than 40 years’ experience in the pump industry. During my 32 years with Flowserve, a global pump manufacturer, I was active in Research ; Development, marketing and sales support, manufacturing operations, field retrofits, troubleshooting and

Contact us

Deciding When to Replace It - When is That Ol

There are several factors to consider when deciding whether to keep an existing boiler or install a new one, but the main factor is the condition of the metal the boiler is made of.

Contact us

Cheaper Heating Oil - BoilerJui

As an impartial service, we guarantee to always show you our best price from a UK nationwide list of suppliers. Just like an auction, each of these suppliers will lower their prices to compete for your order.

Contact us

MAWP vs. Design Pressure - Boiler and Pressur

Recently while trying to finalize a nameplate issue, I had an interesting discussion with one of our fab shops. They kept showing the vessel design pressure (50 psig) as the MAWP on their code nameplate drawings.

Contact us

MHI Superheated Steam Generators One Atmospher

What is superheated steam? What is saturated steam? When water molecules exist in a gaseous-state at a temperature above the boiling temperature of water, it is called the superheated steam-state.When at the boiling-temperature, the steam is called saturated steam.

Contact us

DB-3/4 – Differential Bypass Valve - Xylem Applie

The differential bypass valve is used in systems where heating loads may be excluded from the circuit as zone valves close. It controls the excess flow in the system by acting as a bypass while ensuring adequate flow to the remaining open circuits.

Contact us

How to Make Pot Butter, Cannabutter, ; Marijuan

OTHER CONSIDERATIONS. Here are a few other things to consider while making pot butter. Smell. Pot butter will make your entire house smell for at least a day.

Contact us

Trane vs Carrier vs Lennox Furnace Review 20

Trane, Carrier and Lennox are the “Big 3” of the HVAC world. Their large market shares are fueled by quality, efficient products and huge marketing budgets.

Contact us

HVAC State and Local Licensing Requiremen

There aren’t a lot of building trades that require you to hold more than one card. That can’t be said for the HVAC trade. One of the biggest gripes out there is the sheer number of certifications a guys has to hold to stay above board in the HVAC industry

Contact us

Visual Pump Glossary - pumpfundamenta

ANSI B73.1: this is a standard that applies to the construction of end-suction pumps.It is the intent of this standard that pumps of all sources of supply shall be dimensionnally interchangeable with respect to mounting dimensions, size and location of suction and discharge nozzles, input shafts, baseplates, and foundation bolts.

Contact us